How do you troubleshoot a GEM car charger?

Troubleshooting a GEM car charging Fault LED flashing: when the fault light of your charger flashes, confirm the number of flashes it makes as that will help you verify the kind of error. First confirm if the battery connections are faultless, before proceeding.

How long does it take to charge a GEM battery?

The Way it Works. The batteries are charged with an onboard charger that plugs into a standard 110-volt outlet. It takes approximately six to eight hours to recharge a GEM ® car from a completely discharged state. In addition, with an optional fast charge package, GEM ® cars can be optimally charged in less than one hour.

What happens to the battery in a GEM car?

As batteries wired in series charge and discharge, the individual batteries will be at a different states of charge. Over time, one or two cells will drop out (detected by a hydrometer if a wet cell battery) resulting in low driving range. If the unbalanced battery situation is fixed soon enough, the GEM Car battery life can be extended.

How many miles can you charge a GEM car?

It is hard to say exactly what your range will be, but a typical GEM ®car, used used under proper conditions with fully charged batteries, can get up to 30 miles on a charge.

Gem Car Troubleshooting Manual

Listing Results Gem Car Troubleshooting Manual

About 17 results and 4 answers.

2005 to Current GEM Troubleshooting - Polaris Inc.

the car was first turned on. Release the accelerator pedal, engage the parking brake, select a drive mode, disengage the parking brake, and then push the accelerator pedal. If the problem persists, dealer will need to troubleshoot the accelerator pedal circuit and/or the parking brake assembly. 15

2004 and Earlier GEM Troubleshooting - Polaris Inc.

Charge the car. If the problem persists, dealer will need to troubleshoot the motor controller. 41 Open thermal protector or transistor over temperature. The motor controller is in thermal cutback. Allow cooling and the status code should disappear. If the problem persists after the

Troubleshooting - GEM-CAR Documentation

You might run into this error message while trying to open the Installer. Unable to download definition file. The SSL connection could not be established, see inner exception. To solve this problem, try enabling the TLS 1.2 protocol by following the steps below. Open the Registry Editor and go to HKEY_LOCAL_MACHINE\SYSTEM\CurrentControlSet\Control\SecurityProviders\SCHANNEL\Protocols.

User manuals - GEM-CAR Documentation

User manuals. In this section, you will find detailed user manuals on how to use GEM-CAR and related software. It will include guides for using: GEM-CAR Installer. You can navigate between the user manuals and their sections in the menu at the left or search with keywords with the search bar in the top right corner to find the information you are looking for.

Manuals & Guides - Charging Instructions Polaris GEM

Find everything you need to care for your GEM vehicle from owner’s manuals, quick reference guides, charging information and the latest brochure.

GEM Service Repair Manual PDF

2002-2004 GEM E825 Electric Car Repair Manual PDF Download Download Now; 1999-2001 GEM E825 Electric Car Repair Manual PDF Download Now; 1999-2001 GEM E825 Electric Golf Cart Repair Manual PDF Download Now; 2002-2004 GEM E825 Electric Car Repair Manual PDF Download Now; GEM E825 ELECTRIC VEHICLE WORKSHOP SERVICE REPAIR MANUAL Download Now

How to Troubleshoot a GEM Car – Gem Car Parts Direct

You have to manually rectify this error by unplugging and replugging the cord after 30 seconds. However, if the battery is damaged replace it with a cost friendly one from the GEM car accessories. Five flashes signal that the charger is overheating.

Gem Car Repair and Maintenance-Service Manual PDF PDF

Always store batteries fully charged. If your car is stored in a cold climate, a fully charged battery will not freeze. Always store your car with the disconnect switch turned off. (Remove 48 GND battery cable for cars without a disconnect switch. Refer to operators manual) The charger and controller have a 50 mA continuous draw. This seems small, but over a long period of time it adds up.

Gem Car Service Manual - Car Repair Manual

Feb 19, 2012 . Car Manual for GEM Car Service Manual 2011 Owner's Manual Take Your Vehicle To Your Dealer Or Call Global Electric Motorcars Customer Service At 866 Should Be Followed When Owning And Operating A GEM Car.

GEM e825 Models Service Repair Manual PDF

GEM E825 ELECTRIC CAR 2002-2004 SERVICE MANUAL Download Now. GEM E825 ELECTRIC VEHICLE WORKSHOP SERVICE REPAIR MANUAL Download Now. GEM Global Electric Motorcars E825 Series 1999-2010 Service Repair Workshop Manual Download PDF Download Now.

Purchase reports - GEM-CAR Documentation

GEM-LINKS Internet resources New SMS component New Global Payments integration Upgrade to SQL Server 2019 Upgrading to Windows 10 Release notes Release notes GEM-CAR 2021 GEM-CAR GEM-CAR Version 14.0.0 Version 13.0.3 Version 13.0.2 Version 13.0.1

How to Troubleshoot a GEM Car It Still Runs

Nov 10, 2010 . Your GEM car could become damaged if left for 30 or more days on a low charge. If you are leaving for more than 10 days, you have several options. After checking the water level in the battery, you could leave the car plugged in with the "Main Disconnect Switch" on, and the charger will assess and charge the battery for up to 24 weeks.

Help Center - Customer Support Polaris GEM

Search the Help Center for Polaris GEM electric cars or select a category to browse articles regarding parts and accessories, products recalls, safety bulletins, online shopping, ride command and more.

Frequently Asked Questions

How do you troubleshoot a GEM car charger?

Troubleshooting a GEM car charging Fault LED flashing: when the fault light of your charger flashes, confirm the number of flashes it makes as that will help you verify the kind of error. First confirm if the battery connections are faultless, before proceeding.
How long does it take to charge a GEM battery?

The Way it Works. The batteries are charged with an onboard charger that plugs into a standard 110-volt outlet. It takes approximately six to eight hours to recharge a GEM® car from a completely discharged state. In addition, with an optional fast charge package, GEM® cars can be optimally charged in less than one hour.
What happens to the battery in a GEM car?

As batteries wired in series charge and discharge, the individual batteries will be at a different states of charge. Over time, one or two cells will drop out (detected by a hydrometer if a wet cell battery) resulting in low driving range. If the unbalanced battery situation is fixed soon enough, the GEM Car battery life can be extended.
How many miles can you charge a GEM car?

It is hard to say exactly what your range will be, but a typical GEM®car, used used under proper conditions with fully charged batteries, can get up to 30 miles on a charge.